Wrench.Pro

2019 Chevrolet Blazer Recalls, Issues & Maintenance

The 2019 Chevrolet Blazer carries 2 open NHTSA recalls — most recently covering tires and automatic transmission. Owners report 4 recurring issue clusters, led by “Thermostat fault triggers reduced steering assist warning.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

2 Open Recalls

Source: NHTSA

TIRES

Campaign #21V115000 · Feb 25, 2021

Issue: General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.

Risk: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.

Fix: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign #20V668000 · Oct 29, 2020

Issue: General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.

Risk: Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Fix: GM will notify owners, and dealers will inspect the start-stop transmission accumulator and replace it if any bolts are missing, free of charge. The recall began December 15, 2020. Owners may contact GMC customer service at 1-888-988-7267, Buick Customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313440.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2019 Chevrolet Blazer.

Reported to NHTSA

Thermostat fault triggers reduced steering assist warning

STEERING, ENGINE

49 NHTSA complaints · 2023-02 → 2026-05

“Steering assist reduced message, then no AC, temp gauge stuck at Cold, P0128 error Code”
— Owner report, NHTSA ODI #11701796
“Faulty thermostat. Check engine light comes on due to thermostat getting stuck open and needing to be replaced. This is terrible for the engine and the environment”
— Owner report, NHTSA ODI #11720293
“Engine temperature gauge is not working. Dash is displaying driver assist issue and steering intermittently locks up while moving. Air conditioning does not work and cooling fan is running at high speed”
— Owner report, NHTSA ODI #11694417

Read all complaints on NHTSA →

Transmission shudder and hesitation during acceleration

POWER TRAIN

10 NHTSA complaints · 2020-11 → 2026-06

“The transmission or torque converter has slippage and shuddering that has caused one or both to go bad. My safety was at risk due to this item beginning to fail to cause the inability to accelerate to maintain my position in traffic”
— Owner report, NHTSA ODI #11734708
“This is less an incident and more like a concern. I noticed a slight shudder upon accelerating. It started at lower speeds, approximately 25-30 mph, and shifting between second and third gear”
— Owner report, NHTSA ODI #11521060
“MY CAR HAS A SHUDDER WHEN IT IS CRUISING AT 1500RPMS. IT IS EXTREMELY ANNOYING TO DRIVE WHEN IT FEELS LIKE I AM DRIVING ON RUMBLE STRIPS”
— Owner report, NHTSA ODI #11377037

Read all complaints on NHTSA →

Shift-to-park sensor failure prevents engine shutoff

POWER TRAIN

90 NHTSA complaints · 2021-06 → 2026-07

“The vehicle will not shut off when you shift to park. You are forced to sit in the vehicle for extended periods of time attempting to get the vehicle turned off”
— Owner report, NHTSA ODI #11730819
“The contact owns a 2019 Chevrolet Blazer. The contact stated that upon shifting to park(P) and attempting to turn off the vehicle, the message "Shift to Park" was displayed and an alarm sounded loudly”
— Owner report, NHTSA ODI #11691782
“2019 Blazer with 73,399 miles is in Park, but displays "Shift to Park". System does not recognize that the vehicle is in Park. Vehicle will not turn off even after shifting transmission to drive and then to Park again”
— Owner report, NHTSA ODI #11618468

Read all complaints on NHTSA →

Loss of power steering and brake assist

STEERING, ELECTRICAL SYSTEM, SERVICE BRAKES

4 NHTSA complaints · 2021-10 → 2026-04

“Power steering goes out intermittently while driving”
— Owner report, NHTSA ODI #11734804
“On mutiple occasions I have lost power steering and power brakes. The Brake and Traction Control lights will illuminate on the dash, but the physical buttons do not and are unresponsive”
— Owner report, NHTSA ODI #11436965
“Without warning, the brake pedal on my 2019 Chevy Blazer became hard, almost as if the car was turned off. I was unable to stop and slowly rolled into the back of a semi stopped at a stoplight”
— Owner report, NHTSA ODI #11602686

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

14 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 Chevrolet Blazer reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →