Wrench.Pro

2023 Chevrolet Tahoe Recalls, Issues & Maintenance

The 2023 Chevrolet Tahoe carries 5 open NHTSA recalls — most recently covering software and rear. Owners report 5 recurring issue clusters, led by “Brake system failure with dashboard warning cascade.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

5 Open Recalls

Source: NHTSA

EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE

Campaign #22V903000 · Aug 12, 2022

Issue: General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Fix: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

SUSPENSION:REAR

Campaign #23V642000 · Sep 20, 2023

Issue: General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

Risk: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

Fix: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.

SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP

Campaign #24V674000 · Dec 9, 2024

Issue: General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Fix: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Campaign #25V274000 · Apr 24, 2025

Issue: General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Risk: Engine failure increases the risk of a crash.

Fix: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Campaign #25V619000 · Sep 18, 2025

Issue: General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

Risk: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

Fix: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Chevrolet Tahoe.

2 active NHTSA investigations

Source: NHTSA

  • Loss of motive power due to engine failure

    Action #EA25007 · opened Oct 23, 2025

    The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Year…

    View on NHTSA →

  • Loss of motive power due to engine failure post recall remedy

    Action #EA26005 · opened Aug 20, 2026

    On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been comple…

    View on NHTSA →

Reported to NHTSA

Brake system failure with dashboard warning cascade

SERVICE BRAKES

16 NHTSA complaints · 2024-04 → 2026-06

“I went to reverse and my brakes didn’t work, the error then came on dash “break system failure max speed 43 mph” I then had to drift into a parking lot to wait for my car to stop. Car dealership said they can’t find anything wrong, I have images showing the error”
— Owner report, NHTSA ODI #11643517
“Since 15,394 miles vehicle has experience multiple system failures upon vehicle startup. 2/24, 2/25, 12/25, 1/26. In all of these 4 instances the brakes become spongy/hard, steering wheel locks, and I am not able to control vehicle”
— Owner report, NHTSA ODI #11719052
“On January 21, 2025 while with my family in -15 degrees, the vehicle suddenly went into ABS lock. We were completely immobilized and unable to move the vehicle”
— Owner report, NHTSA ODI #11637911

Read all complaints on NHTSA →

OnStar and electrical module failure

ELECTRICAL SYSTEM

11 NHTSA complaints · 2023-10 → 2026-02

“Onstar Telematics Module failure. Part is on backorder with no ETA. This module failure removes the navigation, Onstar services including safety notifications, clocks can stop working, Android auto/Apple Carplay services are not functional or intermittently working”
— Owner report, NHTSA ODI #11628473
“This is a brand new vehicle with a known problem to GM yet they keep selling them and admit they cannot fix it. The audio system, including the blinker sound, is warning systems and hands free phone capabilities do not work properly, if at all”
— Owner report, NHTSA ODI #11554953
“I purchased a 2023 Chevy Tahoe in Oct 2025. Since then, I have been trying to figure out how to set up the myChevrolet app. The OnStar button doesn’t work so I called OnStar”
— Owner report, NHTSA ODI #11714438

Read all complaints on NHTSA →

Windshield wiper failure during precipitation

VISIBILITY/WIPER

7 NHTSA complaints · 2024-03 → 2026-06

“Following a GM-initiated over-the-air (OTA) software update on May 18, 2026, my vehicle's windshield wipers became permanently inoperable — stuck in the "on" position with no ability to turn them off. This is not a gradual mechanical failure or wear-and-tear issue”
— Owner report, NHTSA ODI #11744525
“For the third time, my windshield wipers quit working in the middle of a rain/snow storm. Have taken the vehicle into GM service under warranty twice, the first time they updated the software but that repair only lasted a few months”
— Owner report, NHTSA ODI #11710992

Read all complaints on NHTSA →

6.2L L87 engine failure and loss of propulsion

ENGINE

125 NHTSA complaints · 2023-12 → 2026-08

“While traveling at 55mph yesterday, I experienced a full engine failure which shut the car off fully while traveling on a single lane double yellow road. I was able to coast to a secure location. The car will not start or go into neutral”
— Owner report, NHTSA ODI #11740051
“On April 10th, while traveling approximately 7 hours from home on a very busy highway in [XXX] , my 2023 Chevrolet Tahoe (6.2L engine) suffered a complete and catastrophic engine failure, requiring a full engine replacement”
— Owner report, NHTSA ODI #11732988
“While traveling on the highway, the vehicle suddenly lost all power. The gas pedal became unresponsive, and the engine ceased functioning entirely—without any prior warning or indicators. I was forced to coast into a nearby parking lot to prevent a potential collision”
— Owner report, NHTSA ODI #11669503

Read all complaints on NHTSA →

Transmission valve body failure and limp mode

POWER TRAIN

25 NHTSA complaints · 2023-10 → 2026-08

“Rear wheels suddenly lock up momentarily during downshift at 30-50 mph (most reproducible 35-40)”
— Owner report, NHTSA ODI #11751780
“Torque converter needed to be replaced, and then a week later still had the same shuttering and loss of power and the valve body needed to be replaced. Got it back and it still is shuddering and hard shifting”
— Owner report, NHTSA ODI #11682088
“Vehicle down shifted hard and dash board lit up. Wouldn’t shift any higher than 4th or 5th gear. Fortunately we were only going about 35mph. If we would have been on the interstate as we had been the 2 previous days on our trip to Florida it could have been deadly”
— Owner report, NHTSA ODI #11660279

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

3 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

3

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Chevrolet Tahoe reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →