Wrench.Pro

2025 Chevrolet Tahoe Recalls, Issues & Maintenance

The 2025 Chevrolet Tahoe carries 1 open NHTSA recall — most recently covering hub. Owners report 5 recurring issue clusters, led by “RPM surge and reduced power mode while accelerating.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

1 Open Recall

Source: NHTSA

WHEELS:HUB

Campaign #26V304000 · May 14, 2026

Issue: General Motors, LLC is recalling certain 2025–2026 Cadillac Escalade, Escalade ESV, Chevrolet Suburban 1500, Tahoe, GMC Yukon, and Yukon XL vehicles with 24-inch wheels. Incorrect bolts may have been installed on the left and right front wheel hubs, which can result in the bolts loosening or deforming over time.

Risk: A bolt that loosens or breaks during vehicle operation can result in loss of vehicle control, increasing the risk of a crash.

Fix: Dealers will replace the front left and right wheel hub bolts, free of charge. Owner notification letters were mailed June 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262554630. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 14, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Chevrolet Tahoe.

1 active NHTSA investigation

Source: NHTSA

  • Loss of motive power due to engine failure post recall remedy

    Action #EA26005 · opened Aug 20, 2026

    On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been comple…

    View on NHTSA →

Reported to NHTSA

RPM surge and reduced power mode while accelerating

POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE

2 NHTSA complaints · 2026-05 → 2026-06

“On June 12, 2026, while operating my 2025 Chevrolet Tahoe, I experienced an apparent powertrain or transmission-related issue. At the time, the vehicle was already exhibiting another defect involving the air conditioning system, with the driver's side blowing hot air and the…”
— Owner report, NHTSA ODI #11744161
“***SAFETY/DANGER*** On April 12th at around 5:30 p.m. my family of five, to include three minor children were returning home from visiting family which live about an hour and a half away and as we're traveling on the freeway at highway speeds, in traffic, our new Tahoe…”
— Owner report, NHTSA ODI #11739602

Read all complaints on NHTSA →

Spontaneous glass shattering

VISIBILITY/WIPER

2 NHTSA complaints · 2026-05 → 2026-05

“On Friday May 1, 2026 while parked at my home, the rear glass lift gate burst into multiple shards. I have taken a few photos of the outside as I found it. In my surprise, I failed to photograph the glass in the interior of the vehicle. I have owned this car since new, since…”
— Owner report, NHTSA ODI #11735517
“As i was driving down the road at approximately 40-45mph the sunroof spontaneously exploded. Sounded like a shotgun going off. Fortunately i had the sun shade shut but still tiny glass shards came in and fell on my child and the entire interior in the mid section of vehicle.”
— Owner report, NHTSA ODI #11735530

Read all complaints on NHTSA →

Engine failure and sudden loss of power

ENGINE

15 NHTSA complaints · 2025-04 → 2026-06

“On May 19, 2026, my 2025 Chevrolet Tahoe suffered a sudden, catastrophic engine failure while traveling at 60 mph on a public roadway. I originally took retail delivery of this vehicle brand new on October 29, 2025, with only 14 miles on the odometer; at the time of the failure,…”
— Owner report, NHTSA ODI #11746197
“*Total Engine Destruction from Thrust Bearing Failure (GM Bulletin 25-NA-307) * Yes, failure has been confirmed at Chevy Dealership (Davis Chevrolet Gainesville FL) * Yes, problem has been reproduced at dealership *Only the dealer service department has confirmed failure *No…”
— Owner report, NHTSA ODI #11718848

Read all complaints on NHTSA →

Loss of brake assist and ABS/ESC warnings

SERVICE BRAKES

6 NHTSA complaints · 2025-09 → 2026-04

“I am filing a safety complaint regarding my 2025 Chevrolet Tahoe Premier for repeated brake assist/braking failures. Most recent incident: While driving, the check engine light came on. I turned the vehicle off for approximately 10 minutes and restarted it, but the check engine…”
— Owner report, NHTSA ODI #11733952
“Driving along the highway in cruise control at about 70mph without any trailer being pulled. Suddenly I got brake errors. ABS, ESC, Trailer brake error failures all popped on the dash warnings. Brakes were unresponsive only applying hard pressure to the brake pedal was…”
— Owner report, NHTSA ODI #11684474

Read all complaints on NHTSA →

Automatic braking activation without obstruction

FORWARD COLLISION AVOIDANCE

2 NHTSA complaints · 2025-10 → 2026-03

“I have a 2025 Chevy Tahoe and the automatic braking system is way too sensitive. When I’m reversing, it constantly slams on the brakes even when I still have enough space and nothing is in my way. It also brakes when people are nearby but not actually in my path.”
— Owner report, NHTSA ODI #11725987
“When backing up the auto braking brakes very hard sudden stop without warning even though no objects near by. Appears to be from shadows and made worse when it is raining and the camera has water on the lense. I turned off the backup auto braking and it still does it.”
— Owner report, NHTSA ODI #11696183

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Chevrolet Tahoe reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →