Wrench.Pro

2024 Gmc Yukon Xl Recalls, Issues & Maintenance

The 2024 Gmc Yukon Xl carries 2 open NHTSA recalls — most recently covering lamp and hard parts internal/mechanical. Owners report 5 recurring issue clusters, led by “Delayed or ineffective engine recall remedy.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

2 Open Recalls

Source: NHTSA

SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP

Campaign #24V674000 · Dec 9, 2024

Issue: General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Fix: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Campaign #25V274000 · Apr 24, 2025

Issue: General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Risk: Engine failure increases the risk of a crash.

Fix: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2024 Gmc Yukon Xl.

2 active NHTSA investigations

Source: NHTSA

  • Loss of motive power due to engine failure

    Action #EA25007 · opened Oct 23, 2025

    The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Year…

    View on NHTSA →

  • Loss of motive power due to engine failure post recall remedy

    Action #EA26005 · opened Aug 20, 2026

    On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been comple…

    View on NHTSA →

Reported to NHTSA

Delayed or ineffective engine recall remedy

ENGINE AND ENGINE COOLING

6 NHTSA complaints · 2025-05 → 2026-01

“The contact owns a 2024 GMC Yukon XL. The contact received notification of NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available”
— Owner report, NHTSA ODI #11669273
“I am filing this complaint regarding GM Recall N252494000 (NHTSA Campaign Number 25V274) for my 2024 GMC Yukon XL (VIN: [XXX] )”
— Owner report, NHTSA ODI #11669610
“Good morning. It’s about the safety recall for loss of propulsion due to manufacturing defects that can lead to engine damage and engine failure. GM notified me about this in September 2025”
— Owner report, NHTSA ODI #11713057

Read all complaints on NHTSA →

Excessive oil consumption and leaks

ENGINE

3 NHTSA complaints · 2025-05 → 2026-06

“Engine oil consumption, low oil every 3000 miles”
— Owner report, NHTSA ODI #11661116
“PURCHASED A GMC DENALI YUKON ULTIMATE XL JUNE LAST YEAR . 103 THOUSAND. bOUGHT IT IN FOR FIRST OIL CHANGE AT 5500 MILES THE CAR HAS BEEN LEAKING OIL ,TOO, nOW ITS BEEN BACK THREE TIMES AND STILL LEAKI9NG OIL”
— Owner report, NHTSA ODI #11658887
“I perform all maintenance on my vehicles, I have previously been a ASE Certified Master Technician, so I know engines and vehicles very well”
— Owner report, NHTSA ODI #11745414

Read all complaints on NHTSA →

Transmission valve body shifting failure

POWER TRAIN

3 NHTSA complaints · 2025-04 → 2026-01

“Transmission will not shift out of 1st and 2nd gear. Backordered Valve Body Nationwide... none in the country. No ETA for this fix. Car has been in the shop over a month”
— Owner report, NHTSA ODI #11654932
“Transmission appears to be lunging and shuttering. Dealer has indicated that the valve body need to be replaced or the vehicle could leave me stranded or without propulsion while driving”
— Owner report, NHTSA ODI #11713448
“vehicle parked for extended period, 7-10 days, entered vehicle on 12/05/25 and proceeded to start - immediately service transmission appeared in display, check engine light on, dash flashing and door locks going up and down and chiming of alarms”
— Owner report, NHTSA ODI #11704297

Read all complaints on NHTSA →

Body panel and trim fit-and-finish defects

EXTERIOR LIGHTING, STRUCTURE, ENGINE

3 NHTSA complaints · 2025-09 → 2025-09

“Hello,I would like to file a complaint for General Motors for untimely recall remedy and failure to fix recall it’s been 6 months since the recall and there’s no remedy no estimate on it and no update from dealer or GM”
— Owner report, NHTSA ODI #11689744
“Windshield needs replacement – one side window installed incorrectly (huge gap) •Trim peeling (inside and outside) •Heavy rust in engine area •Sunroof seals need replacement •All window tints need replacement”
— Owner report, NHTSA ODI #11690084
“Check Engine and transmission alerts appeared in the app; vehicle showed “Check 4x4” while driving, cleared next day”
— Owner report, NHTSA ODI #11690048

Read all complaints on NHTSA →

Engine seizure and loss of propulsion

ENGINE

43 NHTSA complaints · 2025-01 → 2026-08

“Total engine failure at 12,307 miles without warning. The engine turned off while driving on the Interstate - a message appeared on the instrument panel that said "Press start"”
— Owner report, NHTSA ODI #11642840
“The contact owns a 2024 GMC Yukon XL. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended”
— Owner report, NHTSA ODI #11719490
“The engine seized on us. It only has 18,000 miles on it. This could have caused a serious accident! There was no warning, no indication, it just died and would not restart”
— Owner report, NHTSA ODI #11662336

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2024 Gmc Yukon Xl reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →