Wrench.Pro

2025 Gmc Yukon Xl Recalls, Issues & Maintenance

The 2025 Gmc Yukon Xl carries 1 open NHTSA recall — most recently covering hub. Owners report 5 recurring issue clusters, led by “Engine seizure and failure requiring replacement.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

1 Open Recall

Source: NHTSA

WHEELS:HUB

Campaign #26V304000 · May 14, 2026

Issue: General Motors, LLC is recalling certain 2025–2026 Cadillac Escalade, Escalade ESV, Chevrolet Suburban 1500, Tahoe, GMC Yukon, and Yukon XL vehicles with 24-inch wheels. Incorrect bolts may have been installed on the left and right front wheel hubs, which can result in the bolts loosening or deforming over time.

Risk: A bolt that loosens or breaks during vehicle operation can result in loss of vehicle control, increasing the risk of a crash.

Fix: Dealers will replace the front left and right wheel hub bolts, free of charge. Owner notification letters were mailed June 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262554630. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 14, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Gmc Yukon Xl.

1 active NHTSA investigation

Source: NHTSA

  • Loss of motive power due to engine failure post recall remedy

    Action #EA26005 · opened Aug 20, 2026

    On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been comple…

    View on NHTSA →

Reported to NHTSA

Engine seizure and failure requiring replacement

ENGINE

9 NHTSA complaints · 2025-04 → 2026-08

“On May 6, 2026 while driving on the interstate, the vehicle automatically shifted into Neutral, and lost all engine power. The vehicle would not shift back into drive or even 4x4 neutral to be towed. The vehicle was towed to Sam Boswell GMC in Mt Dora, FL”
— Owner report, NHTSA ODI #11742654
“DuraMAX 3.0L LZ0 engine with defective crankshaft thrust bearing caused catastrophic engine failure requiring engine replacement. The event occurred at about 1,000 miles. There is a GM TSB that addresses this issue”
— Owner report, NHTSA ODI #11699723
“Reduced engine power warning light came on at approximately 7600 miles on our new 2025 Yukon xl. Dealer inspected and ultimately decided the engine needs to be replaced due to crankshaft end play out of spec”
— Owner report, NHTSA ODI #11703036

Read all complaints on NHTSA →

Powertrain jerking and unexpected shift to neutral

POWER TRAIN

3 NHTSA complaints · 2025-09 → 2026-05

“Driving the vehicle with my family in it on merrit parkway in ct 230 am on May 10 th Car rpm start going up and making noises and felt like gear not shifting in few seconds later car all sudden on its own shifted to neutral as my speed 55-60 mph was during that moment”
— Owner report, NHTSA ODI #11738342
“Transmission malfunctioned 4 separate times. Engine and service transmission light came on. Vehicle shifted hard and became immobile at certain times. 4 tropes to a dealer for repair. Latest repair was replacing ECM and problem still persists”
— Owner report, NHTSA ODI #11688875
“Starting at around 1300 miles, we noticed jerking upon acceleration. We took it into the dealership at 1500 due to a check engine light. They replaced the coil in cylinder 1”
— Owner report, NHTSA ODI #11711967

Read all complaints on NHTSA →

Electrical system failure and instrument cluster reboot

ELECTRICAL SYSTEM

2 NHTSA complaints · 2026-01 → 2026-03

“The infotainment and instrumentation cluster will reboot while driving. This has happened multiple times while on the express way and while using super cruise”
— Owner report, NHTSA ODI #11713468
“The car was purchased on 8/15/2026. On November 6th 2026 with 3051 miles on all the gauges, electronic dashboard, gps , climate controls, heads up display failed while car was in driving”
— Owner report, NHTSA ODI #11721834

Read all complaints on NHTSA →

Brake system failure and warning malfunction

SERVICE BRAKES, FORWARD COLLISION AVOIDANCE

4 NHTSA complaints · 2025-04 → 2025-11

“My brakes stopped working randomly. Alarms started going off in the car. Thankfully I was able to quickly turn right instead of rolling into traffic. This was terrifying and could have caused a very serious wreck”
— Owner report, NHTSA ODI #11700916
“At approximately 4,300 miles—well within the 3-year/36,000-mile bumper-to-bumper warranty—this truck suffered a catastrophic right-rear brake failure directly attributable to a dealer-installed GMC-approved Brembo Performance Brake Upgrade Package”
— Owner report, NHTSA ODI #11699186
“Roughly one to two times per day, a notification pops up on the infotainment screen stating that the brakes need to be serviced due to the brake assist system failing”
— Owner report, NHTSA ODI #11656684

Read all complaints on NHTSA →

Rear camera and park assist system failure

BACK OVER PREVENTION, FORWARD COLLISION AVOIDANCE

3 NHTSA complaints · 2025-09 → 2025-12

“The rear view camera is not sufficient for full time use. The camera is positioned too low and during times of dawn/night/dusk if a truck of similar size pulls up behind you, your camera is completely blinded by headlights”
— Owner report, NHTSA ODI #11690347
“The image module system has completely failed and never worked in the Yukon. Then it would brake while still accelerating”
— Owner report, NHTSA ODI #11708115
“On August 9th at 5:30PM roughly, while attempting to park using the vehicle’s Park Assist feature, the system failed to function properly—specifically, it failed to detect a pole at the rear of a parking space, did not slow or brake the vehicle”
— Owner report, NHTSA ODI #11688022

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Gmc Yukon Xl reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →