Wrench.Pro

2025 Chevrolet Colorado Recalls, Issues & Maintenance

The 2025 Chevrolet Colorado carries 1 open NHTSA recall — most recently covering owners/service/other manual. Owners report 4 recurring issue clusters, led by “Infotainment and instrument cluster blackout.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

1 Open Recall

Source: NHTSA

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Campaign #26V114000 · Feb 26, 2026

Issue: General Motors has decided that certain 2027 Chevrolet Bolt EV, 2025-2026 Cadillac OPTIQ, Chevrolet Colorado, Equinox EV, GMC Canyon, 2026 Buick Enclave, Envision, Cadillac CT5, Escalade, Escalade ESV, Escalade IQ, Escalade IQL, LYRIQ, VISTIQ, Chevrolet Blazer EV, Corvette Convertible, Corvette Coupe, Corvette Convertible E-Ray, Equinox, Silverado 1500, 2500, 3500, Silverado EV, Suburban 1500, Tahoe, Traverse, GMC Acadia, Hummer EV Pickup, Hummer EV SUV, Sierra 1500, 2500, 3500, Sierra EV, Terrain, Yukon, and Yukon XL vehicles. The radio may not have been set to the correct status to download the electronic owner's manual during production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, “Occupant Protection.”

Risk: Without an owner's manual to consult, owners may not know how to safely use and operate the vehicle, increasing the risk of injury in a crash.

Fix: Dealers will reset the vehicle radio, which will facilitate automatic download of the electronic owner’s manual, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GM customer service at 1-866-467-9700, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. The manufacturer's number for this recall is N252540430. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 26, 2026.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Chevrolet Colorado.

1 active NHTSA investigation

Source: NHTSA

  • Electronic Brake Module Component Failure

    Action #EA26006 · opened Aug 21, 2026

    On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” mes…

    View on NHTSA →

Reported to NHTSA

Infotainment and instrument cluster blackout

ELECTRICAL SYSTEM

4 NHTSA complaints · 2025-04 → 2026-04

“The contact owns a 2025 Chevrolet Colorado. The contact stated that when the vehicle was started, the instrument cluster went black. The vehicle was taken to a local dealer and the contact was informed that there was a Technical Service Bulletin regarding the failure”
— Owner report, NHTSA ODI #11653951
“I own a new 2025 Chevrolet Colorado, purchased on June 23, 2025. Just four days later, on June 27, both the infotainment system and the digital instrument cluster went completely dark, rendering the vehicle unsafe and inoperable. It has only 78 miles on it”
— Owner report, NHTSA ODI #11670050
“The infotainment system does not operate correctly. The screen where the backup camera and all other information is you can not view since the screen is black most of the time. That is also where the light switch is for headlights and such”
— Owner report, NHTSA ODI #11729204

Read all complaints on NHTSA →

Headlight pulsing during heated seat or wheel use

ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VISIBILITY/WIPER

3 NHTSA complaints · 2025-12 → 2026-02

“Any time the heated seats and or steering wheel heat are on the lights pulsate inside and outside the vehicle. I have complained to the dealership and Chevy. Neither one has any answers for this”
— Owner report, NHTSA ODI #11718361
“When using heated seats and heated steering wheel the headlights randomly pulsate and dim - dangerously impacting driver night-time vision / visibility and confusing / disorienting other drivers. Ongoing issue”
— Owner report, NHTSA ODI #11714083
“The headlights flicker/pulse creating visibility issues at night. This occurs when the heated seats are activated. This is a safety concern for myself, passengers, other drivers, and pedestrians”
— Owner report, NHTSA ODI #11707731

Read all complaints on NHTSA →

Master cylinder failure triggering brake warnings

SERVICE BRAKES, FORWARD COLLISION AVOIDANCE

10 NHTSA complaints · 2025-04 → 2026-06

“This truck was purchased May 2025 and currently has 2600 miles. Without any warning the brake light and ABS warning lights came on along with messages reading Brake Assist,ESC, and Trailer Brake require service”
— Owner report, NHTSA ODI #11681437
“Started the vehicle and 4 dash lights were on. The ABS light, the forward collision system light, the BRAKE light, and the traction control light. The vehicle was taken to a dealership and we have been notified by the dealer that it is a Master Brake Cylinder failure”
— Owner report, NHTSA ODI #11680667
“BRAKE PEDAL WENT TO THE FLOOR WHEN I APPLIED THE BRAKES, TOOK TRUCK TO DEALERSHIP. DEALERSHIP REPORTED TO ME THE MASTER CLYLINDER WAS DEFECTIVE AND NEEDED TO ORDER ONE FROM DETROIT”
— Owner report, NHTSA ODI #11656513

Read all complaints on NHTSA →

Transmission failure causing sudden loss of acceleration

POWER TRAIN, ENGINE

4 NHTSA complaints · 2025-04 → 2026-03

“On [XXX] after only 400 miles on the odometer, I experienced complete transmission failure while on a highway and was nearly hit by the vehicle behind me, luckily that did not happen”
— Owner report, NHTSA ODI #11661121
“When I try to accelerate some times my truck doesn’t go. It’s like it’s not even in drive. The check engine light is on and the dealership that I bought it from told me just to drive it because they don’t have a loaner vehicle at this time”
— Owner report, NHTSA ODI #11711066
“The Transmission jumps into 1St gear when spot at a traffic light or when parking.Back seat gap and Forward Collision Warning not functioning”
— Owner report, NHTSA ODI #11724818

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Chevrolet Colorado reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →