The 2018 Ford F 350 carries 2 open NHTSA recalls — most recently covering engine and equipment. Owners report 5 recurring issue clusters, led by “Power tailgate opens unexpectedly while driving.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
ENGINE
Campaign #18V894000 · Dec 18, 2018
Issue: Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Fix: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
EQUIPMENT
Campaign #19V401000 · May 29, 2019
Issue: VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Risk: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Fix: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
What drivers and federal regulators have officially reported about the 2018 Ford F 350.
STRUCTURE
28 NHTSA complaints · 2018-10 → 2026-02
“TAILGATE OPENED ON ITS OWN...TOWING 5TH WHEEL TRAILER...THIS IS SECOND TIME SINCE TAILGATE RECALL WAS DONE. *TR”
“In my 2018 F350, I experienced my power tailgate opening on its own. It happened when the vehicle was unattended and while the vehicle was in motion”
“TAILGATE OPENS UNEXPECTEDLY WHILE DRIVING. THIS HAS HAPPENED SEVERAL TIMES”
BACK OVER PREVENTION
12 NHTSA complaints · 2018-11 → 2024-07
“The contact owns a 2018 Ford F-350. The contact stated while reversing, he became aware that the rear-view camera display failed to display an image. As a result of the failure, the contact reversed into a tree”
“The contact owns a 2018 Ford F-350. The contact stated that while shifted into reverse, the back over prevention screen displayed a black screen, with the “Camera Unavailable” message displayed”
“BACK UP CAMERA GOES BLANK AND SHOWS BLACK ON DISPLAY”
WHEELS
9 NHTSA complaints · 2018-04 → 2024-02
“ALUMINUM WHEEL VALVE STEM LEAKING - TIRE LOOSING APPROXIMATELY 10 PSI PER DAY. TPMS ALARM NOTIFIED ME OF A PROBLEM ON HIGHWAY WHEN PRESSURE REACHED 50 PSIG (SPEC =65) BUT IDENTIFIED THE WRONG TIRE BECAUSE THE SENSORS ARE INCORRECTLY MAPPED”
“RECURRING VALVE STEM LEAKS CAUSING LOW AIR PRESSURE WHILE VEHICLE STATIONARY AND MOVING. FORD DOES NOT HAVE A FIX”
“EXTREME CORROSION AROUND THE VALVE STEM CAUSING THE TIRES TO GO FLAT. NOW HAVE THE 7TH FLAT TIRE ON A TRUCK WITH ONLY 15,000 MILES ON IT”
STEERING, SUSPENSION
117 NHTSA complaints · 2018-10 → 2025-01
“Vehicle steering began shuddering violently while driving at around 50MPH. I had to slow to around 25MPH to get the shuddering to stop. It happened again around 50MPH any time I hit a bump or pothole. At this point the vehicle is unable to be driven at highway speeds”
“THE TRUCK HAS DEATH WOBBLE. WHILE IN MOTION AFTER HITTING ANY ROUGH PATCH OF ROAD THE TRUCKS STEERING WHEEL WILL SHAKE VIOLENTLY AND UNCONTROLLABLY TIL THE OSCILLATION SUBSIDES AFTER REDUCING SPEED BELOW HIGH SPEEDS. THE PROBLEM IS STILL PERSISTING”
“The contact owns a 2018 Ford F-350. The contact stated while driving 65 MPH and driving over a bump on the road, the steering wheel started vibrating and shaking abnormally”
FUEL SYSTEM, DIESEL
10 NHTSA complaints · 2020-08 → 2026-08
“My wife reported a strong smell fuel in the passenger compartment of my 2018 F350 6.7L Diesel vehicle while returning home from work. Upon inspection under the hood when power was turned on I discovered a strong stream of fuel from the filter cap”
“The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had exploded, causing metal shavings intrusion in the fuel system. The dealer determined that the entire fuel system needed to be replaced”
“The fuel filter under the engine began leaking diesel fuel on the hot engine which ignited a fire”
Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
238 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
1
complaints mentioning a crash
5
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2018 Ford F 350 reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.