2020 Ford F 350 Maintenance Schedule
Manufacturer-recommended service intervals for the Intelligent Oil-Life Monitor and open recall alerts for your 2020 Ford F 350.
Personalize for your car and your area
ZIP unlocks trusted shops near you. Mileage unlocks personalized service due dates. Either or both — your call.
Your ZIP stays with us. We share your city with shops, never your ZIP. Read our Promise →
How Ford schedules service: Intelligent Oil-Life Monitor
Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
2 Open Recalls
Source: NHTSASEATS:FRONT ASSEMBLY:RECLINER
Campaign #19V633000 · 28/08/2019
SEATS:FRONT ASSEMBLY:RECLINER
Campaign #19V633000 · 28/08/2019
Issue: Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Risk: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Fix: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
POWER TRAIN:AXLE ASSEMBLY
Campaign #20V599000 · 30/09/2020
POWER TRAIN:AXLE ASSEMBLY
Campaign #20V599000 · 30/09/2020
Issue: Ford Motor Company (Ford) is recalling certain 2020 F-350 trucks equipped with 7.3L gas engines and ambulance prep packages. These vehicles were ordered with Wide Track rear axles, but were built with base (narrower) axles. Depending on the body installed by the body builder, the inner tires on the dual wheel rear axle may contact the body.
Risk: Inner tire contact with the body could result in a tire blowout, potentially causing a loss of vehicle control, increasing the risk of crash.
Fix: Ford will notify owners, and dealers will rebuild the rear axle as a Wide Track axle on vehicles already built. For remaining vehicles, body builders will be given the option to accept the base axle and build a different second unit body that meets Ford's specifications or have the rear axle rebuilt as a Wide Track axle, free of charge. An interim letter notifying owners of the safety risk was mailed on October 23, 2020. The recall began January 11, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S57.
Essential maintenance
Critical for safety and preventing major damage
Engine Oil & Filter
Every 7,500 miReplace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Tire Rotation
Every 10,000 miRotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Brake Inspection
Every 10,000 miInspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Brake Fluid
Every 45,000 miFord specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Important maintenance
Keeps your vehicle running smoothly and efficiently
Engine Air Filter
Every 30,000 miReplace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Automatic Transmission Fluid
Every 150,000 miFord 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Transfer Case Fluid (4WD models)
Every 60,000 miF-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Rear Differential Fluid
Every 100,000 miF-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Spark Plugs
Every 100,000 miIridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Engine Coolant
Every 50,000 miMotorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Recommended maintenance
Extends the life of your vehicle and improves comfort
Cabin Air Filter
Every 20,000 miReplace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Known issues for this vehicle
What drivers and federal regulators have officially reported about the 2020 Ford F 350.
Reported to NHTSA
NHTSA has 180 complaints on file for the 2020 Ford F 350 (2020-05 → 2026-06). We haven't reviewed and grouped them yet for this specific YMM — for now, the full list lives on NHTSA.
Top reported components: POWER TRAIN (51) · STEERING (34) · FUEL SYSTEM (33)
Note: NHTSA also opened 3 defect investigations on this vehicle that closed without action.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Jun 13, 2026. Investigation data refreshed Jun 13, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2020 Ford F 350 reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.