Wrench.Pro

2023 Subaru Forester Recalls, Issues & Maintenance

The 2023 Subaru Forester carries 1 open NHTSA recall — most recently covering driveshaft. Owners report 2 recurring issue clusters, led by “Windshield cracking and chipping.” Subaru's symmetrical AWD system places unusually high demands on differential fluid and transfer case service — skipping these is the most common cause of premature drivetrain wear. Older Subarus with the EJ25 engine (pre-2011) require timing belt replacement; FB and FA engines (2011+) use a maintenance-free chain. Subaru's published intervals below align with the owner's manual Schedule II (severe) which most US drivers qualify for.

1 Open Recall

Source: NHTSA

POWER TRAIN:DRIVELINE:DRIVESHAFT

Campaign #23V754000 · Sep 11, 2023

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2024 Crosstrek, Impreza, 2023-2024 Forester, and 2023 WRX vehicles. The front driveshaft assemblies' outer race may develop cracks and break.

Risk: A broken driveshaft can cause a loss of drive power while driving or vehicle rollaway when the vehicle is in park without the parking brake engaged. Either of these scenarios can increase the risk of a crash.

Fix: Dealers will inspect and replace the left and right front driveshafts as necessary, free of charge. Owner notification letters were mailed January 8, 2024. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's number for this recall is WRP-23.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Subaru Forester.

Reported to NHTSA

Windshield cracking and chipping

VISIBILITY/WIPER

18 NHTSA complaints · 2023-05 → 2026-07

“I purchased a new 2023 Subaru Forester Wilderness just a little over a week ago. I was driving to the dealership to drop off some papers, leaving plenty of room around me, and something small hit my windshield because I didn't see any object. My guess is a small pebble off from somewhere off the road? Instant chip…”
— Owner report, NHTSA ODI #11545366
“Spontaneous windshield crack. I parked car in garage overnight. In the morning, there was a spontaneous crack on passenger side. Not sure if it is related to using car heater for the very first time 2 days prior to the spontaneous crack. The vehicle is 8 months old with 10,000 miles”
— Owner report, NHTSA ODI #11553125
“Spontabeus stress crack in windshield in first 1000 miles.”
— Owner report, NHTSA ODI #11571243

Read all complaints on NHTSA →

EyeSight automatic emergency braking unintended activation

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS

9 NHTSA complaints · 2023-05 → 2026-07

“Eyesight collision braking system engaged as I was rolling up my driveway to go into garage. Garage door was rolling up and was about 5 feet off the ground when Anti Collision system engaged and slammed the brakes on. I was going under 1 mph and would not have hit the door.”
— Owner report, NHTSA ODI #11753115
“In driving our 2023 Subaru Forester at 45mph at 10:00 am in the morning, with NO cars in front of us, in back of us, or on either side of us- suddenly the brakes locked up! Had there been anyone behind us, there could have been a dangerous collision.”
— Owner report, NHTSA ODI #11670232
“Forward collision braking activated for no reason. No traffic in front or behind when activated. Steady speed of 35-40 mph when activated - conditions were clear and dry. No warning prior to incident, message appeared on dash during braking. Seat belts activated and car came to a complete and very abrupt stop.”
— Owner report, NHTSA ODI #11523158

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 6,000 mi

Replace 0W-20 full-synthetic oil and filter every 6,000 miles. WRX/STI 2.0L/2.5L turbo: 3,750 miles. Non-turbo FB engines: 6,000 miles severe / 10,000 normal.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Critical on Subaru AWD — uneven tread depth across all 4 tires (>2/32") forces the center differential to bind, damaging the AWD coupling.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, calipers, and parking brake every 7,500 miles. Outback and Forester pads commonly last 35,000-50,000 miles depending on terrain.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Front Differential / Manual Transmission Fluid

Every 30,000 mi

Replace front differential and manual transmission fluid every 30,000 miles. CVT models use proprietary Subaru CVT fluid — a separate item.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Rear Differential Fluid

Every 30,000 mi

Replace rear differential fluid every 30,000 miles. Use Subaru 75W-90 GL-5 — substitutes can cause whining noises within months.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

CVT Fluid (Lineartronic)

Every 30,000 mi

Subaru CVT models (Outback, Legacy, Forester, Crosstrek, Impreza, Ascent): replace Lineartronic CVT fluid every 30,000 miles severe / 60,000 normal. Subaru High-Torque CVT-II fluid only — incorrect fluid destroys the chain-and-pulley system.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Timing Belt (EJ25 engines, pre-2011)

Every 105,000 mi

Older Subarus with the EJ25 boxer engine (Forester, Outback, Legacy 1996-2010): replace timing belt every 105,000 miles. FB and FA boxer engines (2011+) use a chain — no scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$935–$1175

Shop

~$655–$825

DIY

Pro only

On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 30 months. Subaru's brake hold and EyeSight automatic emergency braking depend on uncontaminated fluid.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. WRX/STI: inspect every oil change due to the higher airflow demand of the turbo intake.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

Iridium plugs every 60,000 miles on FB engines. WRX/STI 2.5L turbo: 30,000 miles due to higher cylinder pressures and EGT.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Coolant

Every 30,000 mi

Subaru Super Coolant (blue): first change at 137,500 miles or 11 years, then every 30,000 miles. Do not substitute green or orange — head gasket sealing chemistry depends on the formula.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Behind the glove box on most Subaru models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

6 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

8

complaints mentioning a crash

4

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Subaru Forester reflects Subaru's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →